Optimization of composite parts of the production process is the introduction of a milestone reusable vacuum enclosures. Compared with the traditional thin-film technology, using it can make the series production of composite parts was simpler, lower cost and faster.
This innovative technology is based on the Wacker silicone rubber products ELASTOSIL ® C 150 and ELASTOSIL ® C 1200. They are platinum catalyzed Truck Tyre cross-linking of the two sub-silicone rubber, with production of high quality vacuum cover the key performance requirements. For example, ELASTOSIL ® C 150 has low viscosity and a few minutes at room temperature hardening of the advantages of no shrinkage. Larger size for the production of vacuum enclosures developed ELASTOSIL ® C 1200 can process significantly extended the time for OTR Tyre nearly 20 minutes. This enables the system to do the vacuum hood for specific applications, especially for small boats, aircraft and wind power equipment industry. Because this process is very economic, so cost savings can be significant.
Tags: good-offices tyre tire Truck-tyre Truck-Tire OTR-Tyre PCR-Tyre Agriculture-Tyre
FUSONG Chinese Academy of Sciences Research Center at the inspection after the excitement, this is the development and production of synthetic rubber, a milestone that China's development and production of synthetic rubber to the international.
Rubber has always been an important strategic materials developed countries, in addition to automotive and other civilian areas in a wide range of use, advanced synthetic rubber is aerospace, naval and other strategic areas of need for precision materials Truck Tyre. With the rapid development of automobile industry in China as a car tire inner tube of butyl rubber and a tire inner liner of the halogenated butyl rubber, the rapid growth in demand, the annual demand exceeds 30 million tons, only recently started the expansion of rice in our province The forest, Bridgestone, Goodyear tire factory on the new Big Three automakers to increase production capacity of 40 million tires. But the domestic need to import 70% of butyl rubber, halogenated butyl rubber or all rely on imports. From the "Eleventh Five-Year", China's synthetic rubber production has key support as OTR Tyre a national development project.
Tags: Tire-industry tyre tire Truck-tyre Truck-Tire OTR-Tyre PCR-Tyre Agriculture-Tyre
Bridgestone Kheda Madhya Pradesh in India's truck and bus radial tire plant. Bridgestone also plans to set up new plant in Chakan to increase the passenger car and truck radial tire production capacity. The total investment amount of the two plants will reach 26 billion rupees, India's Managing Director Hiromi Tanigawa Bridgestone in the Oct. 11 to answer media said.
The new truck tire plant will begin operations in May 2011, initially will produce 200 tires per day. Mr. Tanigawa, Bridgestone in 2006 for India, through the production of radial tire road conditions into the Indian market.
India's rapid economic growth led to the development of automobile industry, truck and bus radial tire demand is growing.
Tags: Eleventh tyre tire Truck-tyre Truck-Tire OTR-Tyre PCR-Tyre Agriculture-Tyre
Three industries to relocate to another mountain Fruitful, October 13, 2010, a large Swiss Rubber Co., Ltd. Anhui annual 1.5 million high-performance steel radial truck tires started in the three mountain Economic Development Zone, which will be built in Wuhu City to fill the gaps in tire manufacturing.OTR Tyre
It is reported that the total investment of 1.2 billion yuan, with a high-performance all-steel radial truck tire production line, the project is expected to put into operation in October 2011. As of 2010 the three mountain industries to relocate to a new bright spot, a large Swiss Rubber Co., Ltd. Anhui development, production and sales, the main high-performance, high-grade radial tires.Truck Tyre
Tags: Eleventh tyre tire Truck-tyre Truck-Tire OTR-Tyre PCR-Tyre Agriculture-Tyre
Munich, Germany, October 12, 2010, WACKER will be the 6th composite materials, polyurethane and plastic FEIPLAR COMPOSITES & FEIPUR international exhibition on display of innovative silicone rubber, almost all the specifications for the efficient production of molded parts with a vacuum hood. FEIPLAR COMPOSITES & FEIPUR 2010 Exhibition will be held November 10-12 in São Paulo, Brazil.OTR Tyre
Optimization of composite parts of the production process is the introduction of a milestone reusable vacuum enclosures. Compared with the traditional thin-film technology, using it can make the series production of composite parts was simpler, lower cost and faster.Truck Tyre
Tags: Eleventh tyre tire Truck-tyre Truck-Tire OTR-Tyre PCR-Tyre Agriculture-Tyre
Encourage the development of safe, energy saving, environmental protection, high-performance radial tires, giant OTR, wide cross-section, a flat tire and passenger tubeless radial truck tires. 2015, passenger car radial tire of the rate of 100% of light truck radial tires 85%, rate of radial truck tires up to 90%; focus on engineering radial tires, radial tires and low-speed air vehicle tire development.
Encourage car companies assemble new tire products to improve the domestic passenger car and truck assembly rate of radial tires, basically the assembly in 2015 and tubeless tire of the meridian. Strictly limit the development of bias tire, in addition to aircraft tires, but no additional bias tire production capacity. Its annual output of 500,000 out of the following natural cotton bias tires and tire cord fabric production line for the skeleton. Limited development of tire radial truck tires.
"Policy" also pointed out the need to accelerate development of isoprene rubber, halogenated butyl rubber and other species, increasing butadiene rubber and styrene butadiene rubber and other varieties of synthetic rubber grades, and gradually increase the proportion of synthetic rubber used and the development of production capacity. Encourage new structure of steel cord and high modulus, low shrinkage polyester cord fabric, tire cord fabric of high tenacity nylon tire reinforcing materials such as the development and use of aramid fibers to accelerate industrialization and application development.
Tags: Tire-industry tyre tire Truck-tyre Truck-Tire OTR-Tyre PCR-Tyre Agriculture-Tyre
October 13, a total investment of 1.2 billion Swiss Rubber Co., Ltd. Anhui large annual output of 1.5 million high-performance all-steel radial truck tires, in the three mountain Economic Development Zone, Wuhu City, construction, filled the city in tire manufacturing blank. In recent years, with the rapid development of Chery Automobile, the combined effect of its formation has attracted more than 400 domestic and foreign auto parts manufacturers located in Wuhu City, the automobile industry chain is constantly spreading.
Tags: Eleventh tyre tire Truck-tyre Truck-Tire OTR-Tyre PCR-Tyre Agriculture-Tyre
In 2009, China's tire industry output reached 380 million, sales income of more than 220 billion yuan this year, production is expected to reach 400 million, China has become the world's largest tire producer. But with the world advanced level, whether the tire processing, manufacturing systems or in the preparation of raw materials, technological innovation and other OTR Tyre aspects there is a big gap. At present, China's tire industry reached a critical "turning point." Accelerate technological upgrading, promote structural adjustment, promote energy conservation, changes in mode of development, nurturing a well-known brands in the coming period the main task of the tire industry.
First, the industry should work together on the upstream and downstream industry chain, continued to increase technology investment and improve the ability of independent R & D and innovation. To create a testing ground and the tire industry, national engineering technology centers, the industry, academia, research cooperation, closely following the development of the tire and cutting-edge technology, through innovation, integration and the introduction of absorption and innovation, breaking the international high-end tire technology and products monopoly status Truck Tyre, continue to nurture with independent intellectual property and advanced technology development capability environment.
Tags: Tire-power tyre tire Truck-tyre Truck-Tire OTR-Tyre PCR-Tyre Agriculture-Tyre
